12-20消耗定额.docx

《12-20消耗定额.docx》由会员分享，可在线阅读，更多相关《12-20消耗定额.docx（15页珍藏版）》请在第一文库网上搜索。

1、广东远光电缆实业有限公司产品材料重量及消耗定额额定电压1220kV交联聚乙烯(X1PE)绝缘电力电缆编号：J/YG4.09-20112011年7月1日共14页第1页版次：第2版2011年7月1日起执行广东远光电缆实业有限公司额定电压1220kV编号：J/YG4.09-2011交联聚乙烯(X1PE)绝缘电力电缆共份第份产品材料重量及消耗定额代替：-1适用范围本产品材料重量及消耗定额根据GB/T12706.2-2008标准和D/YG03-2005电线电缆工艺设计规范编制，适用于生产额定电压12/2OkV交联聚乙烯(X1PE)绝缘电力电缆及其延伸电缆产品。2计算方法2. 1材料计算重量是依据I/YG

2、4.09-2011额定电压12/2Okv交联聚乙烯绝缘电力电缆制造规范和D/YG03-2005电线电缆工艺设计规范的有关规定进行计算。2.2材料消耗定额依据D/YG03-2005电线电缆工艺设计规范的有关规定进行计算。3电缆用材料3. 1填充物1)电缆的缆芯间隙采用PP绳填充。2) ZA型无铠装电缆的缆芯间隙采用玻璃丝绳填充。3.2成缆绕包带1)电缆的缆芯采用双层无纺布重叠绕包。2) ZA、ZB、ZC型无铠装电缆的缆芯采用双层无卤阻燃隔氧带重叠绕包。3.3隔离套1)标准规定型号电缆采用H-90型聚氯乙烯(PVC)或聚乙烯(PE)材料。2) ZB、ZC型电缆采用H-90型聚氯乙烯(PVC)材料。

3、3) ZA型电缆采用ZH-90型聚氯乙烯(PvC)材料。3. 4外护套1） YJVZC-YJV.YJ1V.ZC-YJ1V.YJV22、ZC-YJV22、YJ1V22、ZCTJ1V22采用HI-90型黑色聚氯乙烯（PvC）护套料。批准审核会签标准化编制蒋陆肆郑建凯赵晓宏王勋温志力2） YJY、ZC-YJY、YJ1YZC-YJ1Y、YJV23、ZC-YJV23、Ze-YJ1V23、YJ1V23采用DH-90型黑色聚乙烯（PE）护套料。3） ZA-YJV、ZB-YJV、ZA-YJ1V、ZB-YJ1V、ZATJV22、ZB-YJV22ZA-YJ1V22、ZB-YJ1V22采用ZDH-90型黑色阻燃聚氯

4、乙烯（PVC）护套料。4） ZA-YJYZB-YJY、ZA-YJ1Y.ZB-YJ1YZA-YJV23、ZBTJV23、ZA-YJ1V23ZB-YJ1V23采用ZDH-90型黑色阻燃聚乙烯（PE）护套料。3.5其它未列出各型号电缆用材料为同种材料。4产品材料重量及消耗定额产品材料重量及消耗定额见下表。5其它说明5.1玻璃丝绳重量为PP绳的2.500倍。5.2 无卤阻燃隔氧带重量为无纺布的2.586倍。5.3 ZH-90型PVC护（隔离）套重量为H-90型PVC护（隔离）套1021倍。5.4当电缆有防鼠、防蚁（FSY）要求时,应在护套料中添加适当比例的防鼠、防白蚁母料。防白蚁母料：a.普利离：2%

5、；b.卡安特：5%o防鼠母料：3%o5.5电缆消耗系数表铜导体1.01半导电带1.03内屏1.08绝缘1.08夕卜屏1.05铜丝1.02铜带1.03无纺布1.03填充绳1.04隔离套1.06护套1.06钢带1.03表11220(24)kVYJVxYJY型紧压圆形单芯电力电缆结构尺寸序号数称面成芯标截I11m导体外径m体蔽度m导屏厚m绝缘厚度mm缘蔽度n绝屏厚皿带蔽m铜屏厚m无纺布层X厚义宽m外护套厚度mm品缆径I11n成电外U111X357.00.85.50.80.12X3510.2351.725.5621X508.40.85.50.80.12X3510.2351.827.1631X709.8

6、0.85.50.80.12X3510.2351.828.5641X9511.50.85.50.80.12X351O.2351.930.4651X12012.90.85.50.80.12X4010.2401.931.8661X15014.50.85.50.80.12X401X0.2X402.033.6671X18516.00.85.50.80.12X4010.2402.035.1681X24018.30.85.50.80.12X4010.2402.137.6691X30020.50.85.50.80.12X4010.2402.240.06101X40023.50.85.50.80.12X4010

7、.2402.343.26111X50026.70.95.50.80.12X4010.2402.446.86121X63030.00.95.50.80.12X401X0.2X402.550.36表1(续)1220(24)kVYJV、YJY型紧压圆形单芯电力电缆结构净重序号芯数X标称铜体蔽导屏绝缘(X1PE)缘蔽绝屏带蔽铜屏无纺布外护套(PVC)外护套(PE)截面mm2kg/kmkg/kmkg/kmkg/kmkg/kmkg/kmkg/kmkg/km11X35308.0423.52224.1461.5384.0610.57178.40119.7821X50440.0627.75246.4065.75

8、89.5811.25200.77134.8031X70616.0831.97268.6569.9795.1011.93211.85142.2541X95836.1037.10295.6775.10101.8112.76238.67160.2551X1201056.1341.32317.9379.32107.3313.44250.37168.1061X1501320.1746.14343.3684.14113.6314.22278.50186.9971X1851628.2050.67367.2188.67119.5514.95291.69195.8581X2402112.2657.60403.7

9、795.61128.6216.06328.44220.53913002640.3364.24438.74102.24137.2917.13366.34245.97101X4003520.4473.29486.43111.29149.1218.59414.35278.211115004400.5593.64540.48121.54162.5320.24469.31315.11121X6305544.69104.84592.94131.49175.5421.85526.25353.34表1(续)1220(24)kVYJV.YJY型紧压圆形单芯电力电缆电缆消耗定额序号芯数X标称铜体蔽导屏绝缘(X1P

10、E)缘蔽绝屏带般铜屏无纺布外护套(PVC)外护套(PE)截面mm2kg/kmkg/kmkg/kmkg/kmkg/kmkg/kmkg/kmkg/km11X35311.1225.41242.0764.6086.5810.89189.11126.972150444.4629.97266.1169.0392.2711.59212.82142.8931X70622.2434.53290.1473.4797.9612.29224.57150.784195844.4740.06319.3378.85104.8613.14252.99169.8651X1201066.6944.62343.3683.29110

11、.5513.84265.39178.1961X1501333.3749.84370.8388.35117.0414.64295.21198.2171X1851644.4954.72396.5993.10123.1315.39309.19207.6081X2402133.3962.21436.07100.39132.4816.55348.15233.7691X3002666.7369.38473.84107.35141.4117.65388.32260.73101X4003555.6479.15525.35116.85153.5919.15439.21294.90111X5004444.5610

12、1.14583.72127.62167.4020.85497.47334.O1121X6305600.14113.23640.37138.07180.8022.50557.82374.54表212/20(24)kVYJV22、YJY22型紧压圆形单芯电力电缆结构尺寸序号芯数X标称截面mm导体外径mm体蔽度导屏厚m绝缘厚度mm缘蔽度nm绝屏厚nW铜带屏蔽厚X宽Him无纺布绕包层层X厚义宽隔离套厚度mm铠装钢带层义厚X宽外护套厚度mm品缆径nm成电外11X357.00.85.50.80.12X3510.2351.220.5301.930.3621X508.40.85.50.80.12X3510.2351.22X0.5X301.931.7631X709.80.85.50.80.12X3510.2351.22X0.5X352.033.3641X9511.50.85.50.80.12X3510.2351.220.5352.135.2651X12012.90.85.50.80.12X401X0.2X401.22X0.5X352.136.6